Kia Sorento Gas Tank Won’t Open – While pumping, the fuel spits back out from the tank. It is rather annoying as I lose money fueling and it takes forever to fuel. Normally when I reach about $15. 00 in gas it starts regurgitating.
This happens every time I attempt to fuel. The contact owns a 2005 Kia Sorento. The contact stated that fuel fumes were emitted inside and around the vehicle. The vehicle was taken to the dealer who diagnosed that the fuel tank was leaking and needed to be repaired.
Kia Sorento Gas Tank Won’t Open
The vehicle was not repaired. The manufacturer was made aware of the failure who did not offer any assistance since the vehicle was no longer under warranty. The failure mileage was 79,500. The contact owns a 2003 Kia Sorento.
The contact stated that while driving at various speeds and with the fuel tank gauge at 3/4 or below, the vehicle began to sputter and vibrate before stalling. The contact indicated that the fuel tank needed to be at least 75 percent full to prevent the failure from occurring.
The vehicle was taken to an independent mechanic, who was unable to diagnose the cause of the failure. The manufacturer was notified of the failure. The failure mileage was 209,000. Tl-the contact owned a 2016 kia sorento.
The contact stated that there was an abnormal noise and noticed the vehicle was on fire starting from the fuel tank causing the vehicle to spontaneously blow up in the contact driveway. The fire was extinguished from the fire department.
The vehicle was destroyed. The dealer was not contacted. The manufacturer was notified of the failure. The approximate failure mileage was 10,555. Ak. The contact owns a 2004 Kia Sorento. The contact stated that while refueling the vehicle, the fuel would spew out of the tank.
The contact also stated that the vehicle had been repaired under a manufacturer recall for the same failure in 2012. The vehicle was not repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 135,000.
The VIN was not available. The contact owns a 2006 Kia Sorento. The contact stated that she smelled fuel coming from the vehicle. The vehicle was taken to the dealer for diagnosis, who stated that the fuel tank was leaking and needed to be replaced.
The vehicle was not repaired. The manufacturer was contacted but refused any assistance to the contact. The failure mileage was 72,900 and the current mileage was 73,100. See All problems of the 2006 Kia Motors Sorento
?. When pumping gas there is a sudden spewing of gasoline out of the tank and all over me. I managed several times to get a few gallons in by pumping slowly but the next day the gas gage reads empty and has actually run out of gas several times!
So not only am I having a problem putting gas in, it is immediately draining or leaking out!. See All problems of the 2003 Kia Motors Sorento ?. Tl the contact owns a 2016 kia Sorento.
While attempting to refuel the vehicle, fuel spewed out of the fueling hole. The fuel nozzle would continue to click while fueling. The contact indicated that the failure would occur regardless of how much fuel was in the fuel tank.
The vehicle was taken to nationwide kia (22 w. Timonium rd, Timonium, MD) where it was diagnosed that the vapor recovery line was damaged by insects. The recovery line was repaired and the failure was remedied.
The manufacturer was notified of the failure, but no assistance was offered. The failure mileage was 16,500. See All problems of the 2016 Kia Motors Sorento ?. While exiting my driveway at home (which is on an incline and exits onto a state highway) I lost all braking capability.
When I took the car into my local garage to have the problem diagnosed I was told the brake lines were completely corroded through which caused the loss of braking ability. While attempting the repairs, the mechanic smelled gasoline fumes and found that the fuel lines where they exit the tank have also corroded through.
I started to notice under body corrosion several years ago when the parking brake body attachment points on the rear differential corroded and became dislodged. All of this corrosion seems to be occurring much sooner than I would expect and sooner than I have ever experienced with other vehicles I have owned manufactured by other companies.
Please be advised this is in addition to the fuel tank corrosion previously reported. The underside of the vehicle is eaten up with rust. It is affecting the unit body as well as several structural members of the vehicle.
Have spoken with Kia and they refuse to do anything about it. I feel that this is a serious issue as it is affecting the entire structural integrity of the vehicle. See All problems of the 2011 Kia Motors Sorento
?. The first incident was after refueling. I did not top off. The car just died while idling, took 3 tries to start then lurched when I put it in drive and died again. I was told by the dealer it was because my tank was too full.
I drove 325 miles to an almost completely tank. The indicator stated I still had 76 miles left of fuel. I put 14.5 gallons in (not to the full line) and 12 hours later, it won’t start.
The battery is new. It’s not the battery. See All problems of the 2015 Kia Motors Sorento ?. Every time I have to fill the gas tank on my Kia Sorento 2003 it shoots back the gasoline like a projectile.
It takes an eternity to fill the gas tank if you don’t want to have gas all over you. I have even been kicked out of some service stations because spilling so much gas is a hazard.
Is there any safety recall for this problem? I have not heard a word from Kia. We were attempting to fill the Sorento up with gas when it suddenly spit gas out of the tank when we had only put $11 into it.
It was close to empty when we got to the gas station. We tried a couple of times with the same result. The car would not take anymore gas. The contact owns a 2003 Kia Sorento.
The contact stated that the fuel was not going into the fuel tank properly upon refueling the vehicle and there was a clicking noise as if it were full. The contact had to take an extended period of time to ensure the fuel tank was actually full.
The vehicle was taken to the dealer and they did not diagnose the failure. The vehicle was to be taken to an independent mechanic to diagnose the failure. The vehicle was not included in NHTSA campaign number: 05v353000 (fuel system, gasoline).
The manufacturer was notified of the failure. The approximate failure mileage was 113,000. The 2003 Kia Sorento has a problem with extensive frame rusting, to the point where some owners have had the suspension detach from the frame.
One owner in particular has had issues with the gas tank needing to be replaced, and Kia Motors refuses to do anything about the problem. They built the car, sold it to people, and when consumers have complaints about their vehicle, they (kia) say that they are not responsible.
You need to examine this, because people could get killed by operating an unsafe vehicle. Do something about this now, before it becomes the next pinto. Make kia fix the damn vehicles now!!!. Vehcile was filled up and driven to friends house.
Vehicle was stationary at friends house for few hours. When leaving I smelled the odor of gas. Got light to observe puddle of gas under vehicle. I drove home because it was dark and waited to inspect in the morning.
When re-inspected it was verified gas was leaking from inside an inset on the bottom of the gas tank. I have a 2005 kia and the gas tank seems to be splitting at the seams nothing I did or have done to cause this it has become a big fire risk.
See All problems of the 2005 Kia Motor Sorento ?. Bought the car used drove home. . . . Car sat for a while came out to the smell of gas so strong the gas tank is leaking at the seams.
. . Tank is damp from gas soaking in. . . . . Bought a used tank fixed it and the leak it 100x worse!!!! you can’t see the holes it’s as if it’s not sealing I have read this is a common problem in this car.
And not a cheap fix!!! no recalls?????. The contact owns a 2003 Kia Sorento. While driving at an unknown speed, the vehicle decelerated and stalled without warning. The vehicle was able to restart. In addition, when the contact inserted fuel in the vehicle, fuel spewed out of the fuel tank.
The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 116,000. Dealer said fuel tank had to be replaced due to pitting and corrosion. Please note that the section of the tank that is showing signs of corrosion and leaking are inside the passenger compartment.
Specifically under the rear passenger seat. The vehicle was at the dealer because the check engine light was on. Video is available and we will be advising dealer to return the damaged fuel tank to us.
Purchased the Sorento February 2017, and had noticed a miss in it in November. Sometime in March, the vehicle was down to about a quarter of a tank of gas and it started jerking very badly and losing power.
See all problems of the 2013 Kia Motors Sorento ?. Kia Motor Sorento owners have reported 26 Problems related to other fuel system tank assembly (under the other fuel system category). The most recently reported issues are listed below.
Also please check out the Statistics and reliability analysis of Kia Motor Sorento based on all problems reported for the Sorento.
kia sorento fuel pump recall, kia sorento fuel pump problems, kia sorento fuel pump replacement, kia sorento fuel pump location, kia gas tank recall, 2011 kia sorento fuel pump, 2012 kia sorento fuel filter, kia sorento fuel pump
Emma Nehls is a military writer and historian with a passion for exploring the intricacies of warfare and the human experience within the military. With extensive knowledge and a deep understanding of military strategy, tactics, and historical contexts, Nehls brings a unique perspective to his writings.
